PolyLite PETG
Amended by COMMISSION REGULATION (EU) 2015/830,
According to REGULATION (EC) No 1272/2008
PolyLite™ PETG
Version 1.0
Issue date: 18-06-2019
SDS Record Number: CSSS-TCO-010-131593
Revision date: 18-06-2019
Section 1 Identification of the substance/mixture and of the company/undertaking
1.1 Product identifier:
Identification on the label/Trade name: PolyLite™ PETG
Additional identification: Not available
Identification of the product: See section 3
Index Number: Not available
REACH registration No.: Not available
1.2 Relevant identified uses of the substance or mixture and uses advised against:
1.2.1 Identified uses:
3D Printing Filament.
1.2.2 Uses advised against:
Not available.
1.3 Details of the supplier of the safety data sheet:
Supplier(Only representative):
JF Polymers (Suzhou) Co., Ltd.
Building 6&7&11, No.2, Hai Cheng Road, Chang Shu Economic &
Technological Development Zone, 215513, People’s Republic of China
Zhenggang Cai (zhenggang.cai@polymaker.com)
1.4 Emergency telephone Number:
+86-512-52058005
Available outside office hours?
YES
NO
X
Section 2 Hazards Identification
2.1 Classification of the substance or mixture:
2.1.1 Classification:
According to REGULATION (EC) No 1272/2008, based on available data, the classification criteria are not met:
| REGULATION(EC)No1272/2008 | |
|---|---|
| Hazard classes/Hazard categories | Hazard codes |
| Not classified | N/A |
2.2 label elements:
Hazard Pictograms:
Signal Word(S):
No hazard pictogram is used.
Hazard Statement:
No signal word is used.
Precautionary statement:
Not applicable.
2.3 Other hazards:
Not applicable.
Product name: PolyLite™ PETG
Version #: 1.0 Issue date: 18-06-2019.
| Section 3 Composition/information on ingredients | |
|---|---|
| Substance/Mixture: | Substance |
| Ingredient(s): This product does not contain hazardous ingredients above cut-off value according to Regulation (EC)1272/2008. | |
| Section 4 First aid measures | |
| 4.1 Description of first aid measures: | |
| In all cases of doubt, or when symptoms persist, seek medical attention. | |
| 4.1.1 In case of inhalation: | |
| Remove to fresh air.Get medical attention for any breathing difficulty. | |
| 4.1.2 In case of skin contact: | |
| May irritate damaged skin.Wash off with soap and plenty of water. | |
| 4.1.3 In case of eyes contact: | |
| Immediately flush eyes with plenty of water, lifting upper and lower eyelids occasionally.Get medical attention if irritation persists. | |
| 4.1.4 In case of ingestion: | |
| If large amounts were swallowed,give water to drink and get medical advice. | |
| 4.2 Most important symptoms and effects,both acute and delayed: | |
| The product is not classified as harmful to human health effect. | |
| 4.3 Indication of any immediate medical attention and special treatment needed: | |
| If skin irritation or rash occurs,get medical advice/attention. | |
| Section 5 Firefighting measures | |
| 5.1 Extinguishing media: | |
| Suitable extinguishing media: | |
| Use extinguishing measures that are appropriate to local circumstances and the surrounding environment. | |
| Unsuitable extinguishing media: | |
| Not available. | |
| 5.2 Special hazards arising from the substance or mixture | |
| No specific fire or explosion hazard. | |
| 5.3 Advice for firefighters: | |
| Wear self contained breathing apparatus for fire fighting if necessary. | |
| Section 6 Accidental release measures | |
| 6.1 Personal precautions, protective equipment and emergency procedures: | |
| 6.1.1 For non-emergency personnel: | |
| Avoid dust formation. | |
| 6.1.2 For emergency responders: | |
| Wear an appropriate NIOSH/MSHA approved respirator if dust is generated. | |
| 6.2 Environmental Precautions: | |
| Do not let large amount of product enter drains. | |
| 6.3 Methods and material for Containment and Cleaning up: | |
| Sweep up and shovel.Keep in suitable,closed and properly labelled containers for disposal. | |
| 6.4 Reference to other sections: | |
| See Section 7 for information on safe handling. | |
| See Section 8 for information on personal protection equipment. | |
| See Section 13 for information on disposal. | |
| Section 7 Handling and storage |
| 7.1 Precautions for safe handling: | |
|---|---|
| 7.1.1 Protective measures: | Provide appropriate exhaust ventilation at places where dust is formed. |
| 7.1.2 Advice on general occupational hygiene: | Do not eat, drink and smoke in work areas.Wash hands after use.Remove contaminated clothing and protective equipment before entering eating areas. |
| 7.2 Conditions for safe storage, including any incompatibilities: | Keep container closed in a dry place.Avoid dust formation. |
| 7.3 Specific end use(s): | Not applicable. |
| Section 8 Exposure Controls/Personal Protection | |
|---|---|
| 8.1 Control parameters: | |
| 8.1.1 Occupational exposure limits: | Not available. |
| 8.1.2 Additional exposure limits under the conditions of use: | Not available. |
| 8.1.3 DNEL/DMEL and PNEC-Values: | Not available. |
| 8.2 Exposure controls: | |
| 8.2.1 Appropriate engineering controls: | Use process enclosures, local exhaust ventilation or other engineering controls to keep worker exposure to airborne contaminants below any recommended or statutory limits. If user operations generate dust, fumes or mist, use ventilation to keep exposure to airborne contaminants below the exposure limit. |
| 8.2.2 Individual protection measures, such as personal protective equipment: | |
| Eye/face protection: | Safety glasses when eye contact is possible. |
| Hand protection: | For prolonged or repeated contact use protective gloves. |
| Body protection: | Skin covering working clothes; wear dust-proof overalls if large quantities of dust are generated. |
| Respiratory protection: | Respiratory protection is not required. Where protection from nuisance levels of dust are desired, use type P1 (EN 143) dust masks. Use respirators and components tested and approved under appropriate government standards such as CEN (EU). |
| Thermal hazards: | Wear suitable protective clothing to prevent heat. |
| 8.2.3 Environmental exposure controls: | Avoid discharge into the environment. According to local regulations, Federal and official regulations. |
| Section 9 Physical and chemical properties | |
| 9.1 Information on basic physical and chemical properties: | |
| Appearance: | Solid |
| Colour: | Transparent |
| Odour: | Not available |
| Odour threshold: | Not available |
| pH: | Not available |
| Melting point/range(℃): | 220℃ |
| Boiling point/range(℃): | Not available |
| Flash point(℃): | Not available |
| Evaporation rate: | Not available |
| Flammability limit - lower(%) | Not available |
| Flammability(solid,gas): | Not available |
| Ignition temperature(℃): | Not available |
| Upper/lower explosive limits: | Not available |
$$ 220\ ^{{\circ}\mathrm{C}} $$
| Vapour pressure (20°C): | Not available |
|---|---|
| Vapour density: | Not available |
| Relative Density: | 1.2 |
| Bulk density (kg/m3): | Not available |
| Water solubility (g/l): | Insoluble in water |
| n-Octanol/Water (log Pol/w): | Not available |
| Auto-ignition temperature: | Not available |
| Decomposition temperature: | Not available |
| Viscosity, dynamic (mPa.s): | Not available |
| Explosive properties: | Not available |
| Oxidising properties: | Not available |
| Molecular Formula: | Not available |
| Molecular Weight: | Not available |
| 9.2. Other information: | |
| Fat solubility(solvent-oil to be specified) etc: | Not available |
| Surface tension: | Not available |
| Dissociation constant in water( pKa): | Not available |
| Oxidation-reduction Potential: | Not available |
| Section 10 Stability and reactivity | |
| 10.1 Reactivity: | The substance is stable under normal storage and handling conditions. |
| 10.2 Chemical stability: | Stable at room temperature in closed containers under normal storage and handling conditions. |
| 10.3 Possibility of hazardous reactions: | No dangerous reactions known. |
| 10.4 Conditions to avoid: | Incompatible materials. |
| 10.5 Incompatible materials: | Strong oxidizing agents |
| 10.6 Hazardous decomposition products: | Carbon oxide. |
| Section 11 Toxicological information | |
| 11.1 Information on toxicological effects: | |
| Acute toxicity: | |
| LD50(Oral, Rat) | Not available |
| LC50(Inhalation, Rat) | Not available |
| LD50(Dermal, Rabbit) | Not available |
| Skin corrosion/Irritation: | Not classified |
| Serious eye damage/Irritation: | Not classified |
| Respiratory or skin sensitization: | Not classified |
| Germ cell mutagenicity: | Not classified |
| Carcinogenicity: | Not classified |
| Reproductive toxicity: | Not classified |
| STOT-single exposure: | Not classified |
| STOT-repeated exposure: | Not classified |
| Aspiration hazard: | Not classified |
Section 12 Ecological information
| 12.1Toxicity: | |
|---|---|
| Acute(short-term) toxicity: | |
| LC50(96h,Fish): | Not available |
| LC50(48h,Crustacea): | Not available |
| EC50(72h,Algae/aquatic plants): | Not available |
| Chronic(long-term) toxicity: | |
| NOEC(Fish): | Not available |
| NOEC(Crustacea): | Not available |
| EC50(Algae/aquatic plants): | Not available |
| 12.2Persistence and degradability: | Not available. |
| 12.3Bioaccumulative potential: | Not available. |
| 12.4Mobility in soil: | Not available. |
| 12.5Results of PBT and vPvB assessment: | Not available. |
| 12.6Other adverse effects: | Not available. |
| Section 13 Disposal considerations | |
|---|---|
| 13.1 Waste treatment methods: | Any disposal practice must be in compliance with all local and national laws and regulations.Do not dump into any sewers, on the ground, or into any body of water. |
Section 14 Transport information
| Land transport(ADR/RID) | Inland waterways(ADN) | Sea transport(IMDG) | Air transport(ICAO/IATA) | |
|---|---|---|---|---|
| UN number | Not regulated | Not regulated | Not regulated | Not regulated |
| UN Proper shipping name | Not regulated | Not regulated | Not regulated | Not regulated |
| Transport hazard Class(es) | Not regulated | Not regulated | Not regulated | Not regulated |
| Packing group | Not regulated | Not regulated | Not regulated | Not regulated |
| Environmental hazards | No | No | No | No |
| Special precautions for user | See section 2.2 | See section 2.2 | See section 2.2 | See section 2.2 |
| Transport in bulk according to Annex II of Marpol and the IBC Code | Not regulated | Not regulated | Not regulated | Not regulated |
Section 15 Regulatory information
| 15.1 Safety, health and environmental regulations/legislation specific for the substance or mixture: | |||
|---|---|---|---|
| Relevant information regarding authorization | Not applicable. | ||
| Relevant information regarding restriction | Not applicable. | ||
| Other EU regulations | Employment restrictions concerning young person must be observed. | ||
| For use only by technically qualified individuals. | |||
| Other National regulations | Not applicable | ||
| 15.2 Chemical safety assessment | YES | NO | X |
Section 16 Other information
16.1 Indication of changes:
Version 1.0 Amended by (EU) 2015/830
16.2 Abbreviations and acronyms:
ADR: European Agreement concerning the International Carriage of Dangerous Goods by Road
RID: Regulation for rail International transportation of Dangerous goods
ADN: European Agreement concerning the International Carriage of Dangerous Goods by Inland Waterways
IMDG: Code international maritime dangerous goods code
ICAO: International Civil Aviation Organization
IATA: International Air Transport Association
LC50: median lethal concentration
EC50: The effective concentration of substance that causes 50% of the maximum response.
NOEC: No Observed Effect Concentration
DNEL: derived no-effect level
PNEC: predicted no-effect concentration
16.3 Key literature references and sources for data
ECHA Registered substances data
16.4 Training instructions:
Not applicable.
16.5 Further information:
This information is based upon the present state of our knowledge. This SDS has been compiled and is solely intended for this product.
16.6 Notice to reader:
Employers should use this information only as a supplement to other information gathered by them, and should make independent judgment of suitability of this information to ensure proper use and protect the health and safety of employees. This information is furnished without warranty, and any use of the product not in conformance with this Safety Data Sheet, or in combination with any other product or process, is the responsibility of the user.